Daikin BRC7E61W Service Manual Page 42
- Page / 255
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
SiE25-110 Field Piping and Wiring
Field Piping and Wiring 33
Procedure and Tools for Refrigerant Piping Work
Piping work for R-407C model partially differs from R-22 model in items and procedures of piping work and refrigerant charging due to
different component and higher pressure for R-407C. The below chart shows general work procedure for R-407C model.
Procedure
Prior to work
Work
Determination of work item
Check the refrigerant to be used
Preparing of working drawing
Mounting sleeves and inserts
Installing indoor unit
Refrigerant piping work
Drain piping work
Duct work
Insulation work
Electric work
(Connection wiring / Power supply)
Setting various items
Foundation work for outdoor unit
Installation of outdoor unit
Air tight test
Vacuum drying
Refrigerant additional charging
Test run / Adjustment
Preparing documents required before delivery
Delivery / Operation instruction
Confirm the refrigerant is R-407C or R-22
(1) Check wall thickness of copper tube (Refer to the table "Wall
thickness of refrigerant pipe")
(2) Maintain cleanliness inside of pipe.
(3) Make sure to conduct N
2 blowing when brazing is required.
(4)
Pay attention on pipe flaring and oil to be coated on flared section.
(5) Be sure to use torque wrench.
(1) Make sure to conduct air tight test.
(2) Confirm the pressure of 3.2 MPa does not decrease for 24 hours.
(In case the design pressure of 3.2 MPa)
(1) Vacuum grade is -755 mmHg or lower
(2) Use dedicated vacuum pump
Preparation of documents and drawings in accordance with local
codes and standard.
(1) Confirm the correct amount of refrigerant.
(2) Be sure to charge refrigerant in liquid phase.
(3) Use the dedicated gauge manifold and charging hose.
(4)
The refrigerant amount to be charged is shown in the installation manual.
(5) Record the added refrigerant amount to the record sheet.
- Split System Air Conditioners 1
- SkyAir R-407C 1
- Super Inverter 70 1
- D Series 1
- Split-System 2
- Air Conditioners 2
- Table of Contents iii 4
- 1. Introduction 6
- 1.1.3 Inspection after Repair 8
- 1.1.4 Using Icons 9
- 1.1.5 Using Icons List 9
- SkyAir Super Inverter 70 10
- Heat Pump 10
- Model Name and 12
- Power Supply 12
- : New Model or Changed Model 13
- 1.2 External Appearance 14
- 6 Model Name and Power Supply 15
- Functions 16
- 1. List of Functions 17
- FHYP/FAYP 18
- MIO : Multi Input and Output 19
- Specifications 20
- 1. Specifications 21
- SiE25-110 Specifications 22
- Specifications 13 22
- Specifications SiE25-110 23
- 14 Specifications 23
- Specifications 15 24
- 16 Specifications 25
- FAYP (Wall Mounted Type) 26
- 1.2 60Hz 27
- Specifications 19 28
- 20 Specifications 29
- Specifications 21 30
- 22 Specifications 31
- Remote Controller 32
- 1. Wired Remote Controller 33
- Remote Controller 25 34
- 1.2 Installation 35
- Remote Controller 27 36
- 2. Wireless Remote Controller 37
- 3PA63363-21T-3 38
- 30 Remote Controller 39
- Field Piping and Wiring 40
- 1. Field Piping and Wiring 41
- Procedure 42
- 34 Field Piping and Wiring 43
- 1.2 Field Piping 44
- 36 Field Piping and Wiring 45
- 1.3 Field Wiring 46
- Field Setting 48
- 1. Method of Field Set 49
- 1.2 Field Setting 50
- 42 Field Setting 51
- 1.3 Initial Setting Contents 52
- 1.4 Local Setting Mode No 53
- Field Setting 45 54
- 1.5.3 Filter Sign Setting 55
- Setting Table 56
- Setting The 58
- Receiver 58
- Field Setting 51 60
- 52 Field Setting 61
- 2.1 Indoor Unit PCB 62
- 54 Field Setting 63
- Field Setting 55 64
- 56 Field Setting 65
- RZP71DV1 66
- 125DV1 (E) 67
- RZP100DVAL (E) 67
- RZP125 68
- 3.1 Reference Table 69
- Field Setting 61 70
- 3.3 Emergency Operation 72
- 3.4 Maintenance Mode Setting 73
- Function and Operation 74
- Function and Operation 67 76
- 2. Function Outline 77
- 2.2 Outdoor Unit 78
- Function Outline SiE25-110 79
- 70 Function and Operation 79
- 3. Electric Function Parts 80
- 3.2 Outdoor Unit 81
- ±0.15(MPa) 82
- 4. Function Details 83
- SiE25-110 Function Details 84
- Function and Operation 75 84
- Auto-restart 87
- Function 87
- Using Conditions 88
- Thermostat 88
- Program Dry 89
- Fan and flap 90
- 4.2.1 Restart standby 91
- 4.2.2 Retry Control 91
- 4.2.3 Forced Thermostat OFF 91
- Indoor air temperature 92
- Calculates and controls the 92
- 4.2.8 Starting control 93
- 4.2.9 Compressor step control 94
- 4.2.11 Fan step table 95
- Discharge pipe temperature 96
- 70˚C 75˚C 96
- [Operation frequency control] 98
- Upper limit current (A) 100
- 4.2.23 Oil recovery operation 101
- 4.2.24 Defrost control 102
- 4.2.27 Setting mode 105
- Emergency 106
- Operation 106
- 5. Operation Range 107
- Troubleshooting 108
- SiE25-110 109
- 100 Troubleshooting 109
- 1. Maintenance Inspections 110
- Correlation of Air 111
- Conditioner’s 111
- Operation Status 111
- Running Current 111
- R407C(Liquid side) 112
- R407C(Gas side) 112
- Cautions in 114
- Did you allow 3 minutes to 115
- 108 Troubleshooting 117
- Troubleshooting 109 118
- Immediately 120
- 112 Troubleshooting 121
- Troubleshooting 113 122
- Troubleshooting 115 124
- 116 Troubleshooting 125
- All models of SkyAir series 126
- Faulty installation 126
- Carpet spread room 127
- Animal's hair 127
- 120 Troubleshooting 129
- Controller 130
- 122 Troubleshooting 131
- Troubleshooting 123 132
- 124 Troubleshooting 133
- Contents 134
- Troubleshooting 129 138
- LED Display 139
- Indoor Unit 140
- Outdoor Unit 141
- 134 Troubleshooting 143
- Troubleshooting 135 144
- 6.5 Failure of Drain System 146
- 138 Troubleshooting 147
- Troubleshooting 139 148
- Troubleshooting 141 150
- Troubleshooting 143 152
- 144 Troubleshooting 153
- Troubleshooting 145 154
- 146 Troubleshooting 155
- Troubleshooting 147 156
- 148 Troubleshooting 157
- 5 1 — 2 — 3 — 4 — 158
- 5 1 4 2 3 3 3 4 3 159
- 5 H1P 4 H2P 3 161
- 6.18 Compressor Motor Lock 162
- 9 1 3 2 3 3 4 4 4 164
- 5 1 3 2 3 3 3 4 3 165
- 5 1 4 2 4 3 3 4 3 169
- Troubleshooting 161 170
- H9,J3,J5,J6 171
- 5 1 3 2 3 3 3 4 4 173
- 5 1 3 2 3 3 4 4 3 174
- 5 1 3 2 4 3 4 4 4 176
- 5 1 4 2 4 3 4 4 4 178
- PCB and Inverter PCB) 180
- 6.31 Open Phase 182
- 5 1 4 2 3 3 3 4 3 184
- 5 1 4 2 4 3 3 4 3 185
- 5 1 — 2 — 3 — 4 — 186
- 178 Troubleshooting 187
- Troubleshooting 179 188
- Outdoor Unit) 190
- Troubleshooting 2 191
- Remote Controller) 192
- 184 Troubleshooting 193
- Troubleshooting 185 194
- Troubleshooting 187 196
- *RZP71-140D models only 197
- Troubleshooting 189 198
- 192 Troubleshooting 201
- Check for Thermistors 202
- Voltage Measuring Method 203
- Removal Procedure 204
- 1. FHYCP71~140D 205
- 1.2 Removal of Air Filter 206
- SiE25-110 FHYCP71~140D 208
- Removal Procedure 199 208
- Procedure Points 208
- FHYCP71~140D SiE25-110 209
- 200 Removal Procedure 209
- 1.5 Removal of Swing Motor 210
- 202 Removal Procedure 211
- 1.6 Removal of Switch Box 212
- Tilt the switch box in the 213
- (Status after removal) 213
- 1.7 Removal of PC Board 214
- 206 Removal Procedure 215
- Thermistor 216
- 1.9 Removal of Fan Motor 217
- Removal Procedure 209 218
- 212 Removal Procedure 221
- 2. RZP71~140D 222
- 2.3 Removal of PC Board 225
- SiE25-110 RZP71~140D 226
- Removal Procedure 217 226
- 2.4 Removal of Switch Box (A) 227
- 2.5 Removal of Switch Box (B) 228
- 2.8 Removal of Four Way Valve 232
- RZP100~140D) 234
- RZP71~140D SiE25-110 235
- 226 Removal Procedure 235
- Appendix 236
- 3D034160 237
- 3D034161 237
- 3D034162 238
- 3D032530 239
- 3D027503 240
- 3D027747 241
- 3D027748 242
- 3D032604 243
- 3D032603 244
- 3D032880B 245
- 3D032881B 246
- 3D032882B 247
- Index iii 250
- Drawings & Flow Charts 252
- Zandvoordestraat 300 255
- B-8400 Ostend - Belgium 255
Related products and manuals for Remote controls Daikin BRC7E61W
Remote controls Daikin ARC433B46 User Manual
(34 pages)
(34 pages)
Remote controls Daikin FTXD User Manual
(174 pages)
(174 pages)
Remote controls Daikin BRC7E61W Service Manual
(266 pages)
(266 pages)
Remote controls Daikin BRC1E72 Setup Guide
(36 pages)
(36 pages)
Remote controls Daikin BRC1E51A7 User Manual
(26 pages)
(26 pages)
Remote controls Daikin BRC1D517 User Manual
(21 pages)
(21 pages)
Remote controls Daikin BRC1D527 User Manual
(20 pages)
(20 pages)
Remote controls Daikin BRC1D527 User Manual
(22 pages)
(22 pages)
© 2020, manymanuals.com. All rights reserved. | 0.753 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals