Daikin ATX20JV1B Specifications Page 147
- Page / 156
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
SiBE041010 Outdoor Unit
Removal Procedure 137
2.6 Removal of Compressor
Procedure Warning Be sure to wait 10 minutes or more after turning off all power supplies
before disassembling work.
Step
Procedure Points
1. Remove the peripheries.
Warning
If refrigerant gas leaks during
the work, ventilate the room.
(If the refrigerant gas is
exposed to flames, toxic gas
may be generated.)
Provide a protective sheet or
a steel plate so that the
brazing flame cannot
influence peripheries.
Be careful so as not to burn
the compressor terminals or
the name plate.
Be careful so as not to burn
the heat exchanger fin.
Warning
Since it may happen that
refrigerant oil in the
compressor catches fire,
prepare wet cloth so as to
extinguish fire immediately.
In case of difficulty with gas
brazing machine
1. Disconnect the brazed part
where is easy to disconnect
and restore.
2. Cut pipes on the main unit
with a tube cutter in order to
make it easy to disconnect.
Cautions for restoration
1. Restore the piping by non-
oxidation brazing.
2. It is required to prevent the
carbonization of the oil inside
the four way valve and the
deterioration of the gaskets
affected by heat. For the
sake of this, wrap the four
way valve with wet cloth and
provide water so that the
cloth does not dry and avoid
excessive heating. (Keep
below 120°C)
Note: Do not use a metal
saw for cutting pipes by all
means because the sawdust
comes into the circuit.
Remove the four
way valve, the
terminal cover and
the lead wire for
compressor so as
not to burn them.
1
Unscrew the 3 nuts of
the compressor.
2. Remove the compressor.
1
2
Before working,
make sure that the
refrigerant is empty
in the circuit.
Be sure to apply
nitrogen
replacement when
heating up the
brazed part.
Heat up the brazed part
of the discharge side
and disconnect.
Heat up the brazed part
of the suction side and
disconnect.
3
Lift the compressor up
and remove it.
Caution
From the viewpoint of
global environment
protection, do not
discharge the
refrigerant gas in the
atmosphere. Make
sure to recover the
refrigerant gas with
the recovery system.
Caution
From the viewpoint of
global environment
protection, make sure
to use a vacuum
pump for air purging.
(R12022)
(R7422)
Discharge side
Suction side
(R7423)
(R7424)
- Inverter Pair 1
- Wall Mounted Type 2
- J-Series 2
- Table of Contents ii 3
- Table of Contents iv 5
- 1. Introduction 6
- 1.2 Used Icons 10
- List of Functions 11
- 1. Functions 12
- Specifications 13
- 1. Specifications 14
- 50 Hz, 230 V 15
- Printed Circuit Board 18
- Connector Wiring Diagram 18
- 1.1 Indoor Unit 19
- PCB(2): Display PCB 20
- PCB Detail PCB(1): Filter PCB 22
- PCB(2): Main PCB 22
- Function and Control 23
- 1. Main Functions 24
- 1.2 Airflow Direction Control 26
- (R11975) 27
- 1.4 Program Dry Operation 28
- 1.5 Automatic Operation 29
- 1.6 Thermostat Control 30
- 1.7 NIGHT SET Mode 31
- 1.8 ECONO Operation 32
- (R11976) 33
- 2. Operation OFF 33
- 3. POWERFUL operation is OFF 33
- 1.10 Other Functions 34
- 2. Function of Thermistor 35
- 3. Control Specification 36
- 3.2 Frequency Control 37
- 3.3.1 Preheating Operation 39
- 3.3.4 3-minute Standby 40
- 3.5 Input Current Control 41
- 3.7 Heating Peak-cut Control 42
- 3.8 Outdoor Fan Control 43
- 3.10 Defrost Control 44
- Function and Control 35 45
- 36 Function and Control 46
- Function and Control 37 47
- 3.12 Malfunctions 48
- 3.13 Forced Operation Mode 49
- Operation Manual 50
- 1. System Configuration 51
- 2. Operation Manual 52
- To start operation 53
- To stop operation 53
- Operation Manual SiBE041010 54
- 44 Operation Manual 54
- To adjust the horizontal 55
- (louvers) 55
- 〈HEAT〉 The flap will go down 56
- POWERFUL Operation 57
- ECONO Operation 58
- TIMER Operation 59
- To use ON TIMER operation 60
- Service Diagnosis 61
- 1. Caution for Diagnosis 62
- TIMER CANCEL button 64
- < ARC433 Series > 64
- Service Diagnosis 55 65
- 56 Service Diagnosis 66
- 4. Troubleshooting 67
- Troubleshooting SiBE041010 68
- 58 Service Diagnosis 68
- Model Type Connector 68
- SiBE041010 Troubleshooting 69
- Service Diagnosis 59 69
- Troubleshooting 70
- Check No.06 70
- Refer to P.92 70
- Service Diagnosis 61 71
- (R12038) 72
- Service Diagnosis 63 73
- 64 Service Diagnosis 74
- Service Diagnosis 65 75
- 66 Service Diagnosis 76
- Service Diagnosis 67 77
- 4.10 Compressor Lock 78
- 4.11 DC Fan Lock 79
- 70 Service Diagnosis 80
- Service Diagnosis 71 81
- 72 Service Diagnosis 82
- (R11950) 83
- 74 Service Diagnosis 84
- Service Diagnosis 75 85
- 76 Service Diagnosis 86
- Check No.29 87
- Refer to P.99 87
- 78 Service Diagnosis 88
- Service Diagnosis 79 89
- 80 Service Diagnosis 90
- Service Diagnosis 81 91
- Refer to P.93 92
- Check No.09 92
- Refer to P.94 92
- Service Diagnosis 83 93
- 84 Service Diagnosis 94
- Service Diagnosis 85 95
- 86 Service Diagnosis 96
- 4.23 Refrigerant Shortage 97
- Check No.04 98
- Refer to P.90 98
- Service Diagnosis 89 99
- 5. Check 100
- Check No.05 101
- Resistance range 102
- Check No.07 103
- Check No.08 103
- Check SiBE041010 104
- 94 Service Diagnosis 104
- 5.1.9 Power Module Check 105
- 96 Service Diagnosis 106
- SiBE041010 Check 107
- Service Diagnosis 97 107
- 98 Service Diagnosis 108
- (R12025) 109
- Removal Procedure 110
- 1. Indoor Unit 111
- (R11959) 114
- Fan guard 114
- 1.3 Removal of Front Panel 115
- 1.4 Removal of Front Grille 116
- Left Center Right 117
- (R11268) 118
- Earth wire 119
- Bottom frame 120
- Vertical blade ASSY 120
- Shield plate (2) 121
- Indoor Unit SiBE041010 122
- 112 Removal Procedure 122
- Step Procedure Points 122
- Wooden base 125
- Drain hose 125
- Extension drain hose 125
- Connecting wires 125
- Gas piping 126
- Liquid piping 126
- Auxiliary piping 126
- Piping fixture 126
- (R8041) (R11269) 127
- 1.8 Removal of Fan Rotor 128
- Fan rotor 129
- Fan motor 129
- 120 Removal Procedure 130
- 1.9 Exchange of Drain Hose 131
- 2. Outdoor Unit 132
- Top panel 133
- Front panel 133
- Discharge grille 133
- Projection (rear side) 133
- Lead wire Outdoor fan 134
- Guard net 135
- Right side panel 136
- Discharge pipe thermistor 137
- Electrical box 138
- Terminal board 139
- Control PCB 139
- BrownWhite 139
- (R11962) 140
- (R12021) 141
- 2.4 Removal of Sound Blanket 142
- SiBE041010 Outdoor Unit 143
- Removal Procedure 133 143
- Procedure Points 143
- 2.5 Removal of Four Way Valve 144
- Removal Procedure 135 145
- Outdoor Unit SiBE041010 146
- 136 Removal Procedure 146
- 2.6 Removal of Compressor 147
- SiBE041010 148
- 138 Others 148
- 1. Others 149
- 1.2 Field Settings 150
- SiBE041010 Others 151
- Others 141 151
- Appendix 152
- 1. Piping Diagrams 153
- 1.2 Outdoor Unit 154
- 2. Wiring Diagrams 155
- Cautions on product corrosion 156
Related products and manuals for Split-system air conditioners Daikin ATX20JV1B
(256 pages)
(15 pages)
(12 pages)
(72 pages)© 2020, manymanuals.com. All rights reserved. | 0.169 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals